What are the most common problems with the 2007 Volvo S80?

Structure has the most complaints at 6, then electrical, engine and steering at 4 each. In samples we read, owners describe subframe rust, headlight wiring, oil leaks and power steering hose failures.

Does the 2007 Volvo S80 have recalls?

Yes, 5, covering the seat belt cable, power steering hose, a portable GPS battery, tire label and TPMS software, and wiper software.

What MPG does the 2007 Volvo S80 get?

The EPA lists 19 combined for the 3.2L 6-cyl and 18 combined for the 4.4L 8-cyl.

How many complaints does the 2007 Volvo S80 have?

NHTSA has 24, with no crashes, fires or injuries reported.

2007 Volvo S80 Problems, Recalls and MPG

NHTSA has 24 owner complaints for the 2007 Volvo S80, and none mention a crash, fire or injury^[1]. The model year also has 5 recalls, so check that each one was done before you buy^[2].

24owner complaints^[1]

5recalls^[2]

18–19MPG combined (EPA)^[3]

Problems
Recalls
Fuel economy
Safety
Engine and size
By year
Verdict
FAQ

Most reported problems

Owners filed 24 complaints with NHTSA^[1]. These are unverified reports, and one complaint can name several parts^[1]. The counts below show where owners pointed.

Structure, 6 complaints^[4]. In a sample of complaints we read, four describe rust on the front subframe, the frame piece that supports the front suspension, steering and engine. Some of those owners say it affects V8 models^[4]. One describes water leaking in near the windshield.
Electrical system, 4 complaints^[5]. Owners in our sample describe headlight wiring that shorted or bulbs that failed. One describes wipers that would not behave.
Engine, 4 complaints^[6]. Two of the four in our sample describe oil leaking.
Steering, 4 complaints^[7]. In a sample of complaints we read, owners describe a power steering hose or pump failing and the wheel becoming hard to turn.

The samples are small, so treat them as examples of what owners reported, not as a ranking of failure rates. Smaller groups had 3 or fewer complaints each^[8]^[9]^[10]^[11].

Recalls

NHTSA lists 5 recalls for this model year^[2]. Newest first:

Seat belt cable (20V378). The steel cable that holds the front seat belt anchor can wear out over time. Then the belt may not hold the person in a crash, which raises injury risk. Dealers replace the anchor cable on both front seats. The recall began December 10, 2020^[12].
Power steering hose (11V378). On some 2007 S80s built from March 8, 2006 through May 16, 2007, the return hose may have been routed wrongly^[13]. It can burst and leak fluid, and the driver can suddenly lose power steering. Dealers inspect the routing and repair it free. The fact lists the start as expected in August 2011^[13].
Portable GPS battery (10V566). The battery in certain Garmin 760 portable GPS units may overheat and could cause a fire^[14]. Owners are told to stop using the unit and check with Garmin. The battery is replaced free. The recall began November 18, 2010^[14].
Tire label and TPMS software (10V335). The tire label and a page in the owner's manual show a wrong maximum inflation pressure. The tire pressure monitor software also has a wrong trigger level. Dealers update the labels and software free. The fact lists the start as expected on or about August 27, 2010^[15].
Wiper software (09V139). Software in the central electronic module may keep the wipers from working, or turn them on by themselves. That adds crash risk in bad weather. Dealers inspect the module and update the software free. The recall began May 15, 2009^[16].

One owner complaint in our sample says a steering hose failure happened on a car that was not part of the steering recall^[7]. Ask a dealer to check your VIN.

Fuel economy

EPA lists three versions, all on premium fuel.

Version	City / highway / combined MPG	Annual fuel cost
3.2L 6-cyl, front-wheel drive^[17]	16 / 25 / 19	$4,350
3.2L 6-cyl, all-wheel drive^[3]	16 / 24 / 19	$4,350
4.4L 8-cyl, all-wheel drive^[18]	15 / 23 / 18	$4,550

EPA's fuel cost uses its current fuel price assumptions, not what gas cost when the car was new.

Safety ratings

NHTSA lists the 2007 S80 as not rated in its 5-Star Safety Ratings^[19]. That means there is no star score to compare.

Engine and size

The EPA lists a 3.2L 6-cylinder and a 4.4L 8-cylinder^[3]^[18]. Dimensions are Canadian-market specifications and can differ slightly from US models.

Measure	3.2 V6 AWD	4.4 V8 AWD
Length	191 in	191 in
Width	73 in	73 in
Height	59 in	59 in
Wheelbase	112 in	112 in
Curb weight	3,486 lb	3,840 lb

Source facts:^[20]^[21].

How 2007 compares with other years

Owner complaints filed with NHTSA for each S80 model year. The 2007 is highlighted^[2].

Show the numbers

Model year	Complaints	Recalls
1999	199	4
2000	318	4
2001	164	7
2002	42	4
2003	26	5
2004	50	4
2005	15	5
2006	12	3
2007	24	5
2008	26	7
2009	16	5
2010	27	5
2011	5	4
2012	8	3
2013	8	3
2014	1	1
2015	7	2
2016	6	2

The 2007 model year has 24 complaints and 5 recalls^[2]. Several years have more complaints: 1999 to 2004, 2008 with 26 and 2010 with 27^[2]. Others have fewer: 2005, 2006, 2009 and 2011 through 2016^[2]. For recalls, 2001 and 2008 have 7 each, more than the 5 for 2007^[2]. Counts are not adjusted for sales, so they show what was filed, not how likely a problem is.

Should you buy a used 2007 S80?

The complaint count is moderate for this model, and no complaint reports a crash, fire or injury^[1]^[2]. Ask for proof that all 5 recalls were done, especially the steering hose and seat belt cable^[12]^[13]. Have a mechanic look at the front subframe for rust, and check for oil leaks and headlight wiring problems, since owners in our samples describe them^[4]^[5]^[6]. Weigh fuel cost too, at about $4,350 to $4,550 a year on EPA's assumptions^[3]^[18]^[17].

Frequently asked questions

What are the most common problems with the 2007 Volvo S80?: Structure has the most complaints at 6, then electrical, engine and steering at 4 each^[4]^[5]^[6]^[7]. In samples we read, owners describe subframe rust, headlight wiring, oil leaks and power steering hose failures.
Does the 2007 Volvo S80 have recalls?: Yes, 5, covering the seat belt cable, power steering hose, a portable GPS battery, tire label and TPMS software, and wiper software^[12]^[13]^[14]^[15]^[16].
What MPG does the 2007 Volvo S80 get?: The EPA lists 19 combined for the 3.2L 6-cyl and 18 combined for the 4.4L 8-cyl^[3]^[18]^[17].
How many complaints does the 2007 Volvo S80 have?: NHTSA has 24, with no crashes, fires or injuries reported^[1].

Facts and sources

NHTSA has 24 owner complaints on file for the 2007 Volvo S80 (0 mention a crash, 0 a fire, 0 injuries, 0 deaths reported). NHTSA vehicle records
Owner complaints and recalls for every Volvo S80 model year (chart above). NHTSA recall database
EPA rating for S80 AWD, 3.2L 6-cyl, Automatic (S6), Premium, 4-Wheel or All-Wheel Drive: 16 city / 24 highway / 19 combined MPG; EPA estimated annual fuel cost $4,350. EPA / DOE fueleconomy.gov
6 complaints name the structure component group (0 crashes, 0 fires, 0 injuries). NHTSA vehicle records
4 complaints name the electrical system component group (0 crashes, 0 fires, 0 injuries). NHTSA vehicle records
4 complaints name the engine component group (0 crashes, 0 fires, 0 injuries). NHTSA vehicle records
4 complaints name the steering component group (0 crashes, 0 fires, 0 injuries). NHTSA vehicle records
3 complaints name the unknown or other component group (0 crashes, 0 fires, 0 injuries). NHTSA vehicle records
2 complaints name the visibility component group (0 crashes, 0 fires, 0 injuries). NHTSA vehicle records
2 complaints name the visibility/wiper component group (0 crashes, 0 fires, 0 injuries). NHTSA vehicle records
2 complaints name the exterior lighting component group (0 crashes, 0 fires, 0 injuries). NHTSA vehicle records
Recall 20V378, filed June 30, 2020: Seat Belts › Front. NHTSA recall database
Recall 11V378, filed July 26, 2011: Steering › Hydraulic Power Assist › Hose, Piping, And Connections. NHTSA recall database
Recall 10V566, filed November 8, 2010: Equipment › Electrical › Navigational System(Global Positioning System). NHTSA recall database
Recall 10V335, filed July 22, 2010: Tires › Pressure Monitoring And Regulating Systems. NHTSA recall database
Recall 09V139, filed April 29, 2009: Electrical System › Software. NHTSA recall database
EPA rating for S80 FWD, 3.2L 6-cyl, Automatic (S6), Premium, Front-Wheel Drive: 16 city / 25 highway / 19 combined MPG; EPA estimated annual fuel cost $4,350. EPA / DOE fueleconomy.gov
EPA rating for S80 AWD, 4.4L 8-cyl, Automatic (S6), Premium, 4-Wheel or All-Wheel Drive: 15 city / 23 highway / 18 combined MPG; EPA estimated annual fuel cost $4,550. EPA / DOE fueleconomy.gov
NHTSA 5-Star Safety Ratings, 4 DR FWD/AWD: not rated. NHTSA vehicle records
Transport Canada specifications via NHTSA vPIC, S80 4DR SEDAN AWD 3.2 V6: length 191 in, width 73 in, height 59 in, wheelbase 112 in, curb weight 3,486 lb (converted from centimeters and kilograms). vpic.nhtsa.dot.gov
Transport Canada specifications via NHTSA vPIC, S80 4DR SEDAN AWD 4.4 V8: length 191 in, width 73 in, height 59 in, wheelbase 112 in, curb weight 3,840 lb (converted from centimeters and kilograms). vpic.nhtsa.dot.gov

Complaints submitted to NHTSA by owners; unverified reports, one complaint can name several components. Complaint counts are not normalized by sales; compare years of the same model, not different models. EPA annual fuel cost uses EPA's current fuel price assumptions, not the price when the car was new. Horsepower is the rating listed for EPA test vehicles. Dimensions are Canadian-market specifications and can differ slightly from US models.

2007 Volvo S80: problems, recalls and fuel economy